Get the Latest Investment Ideas Delivered Straight to Your Inbox. Subscribe

How a Switch Back to Coal Could Halt the Natural Gas Rally

Share on Stocktwits

Source:

"When will electricity producers in the U.S. switch from natural gas back to coal? It's an important question this week as natural gas prices are breaking out above recent lows."

When will electricity producers in the US switch over from using natural gas back to coal?

It's an important question this week as natural gas prices are breaking out above their recent low trough in the $2.60/mcf-$3.10/mcf (million cubic feet) range.

Electricity producers in the US decide natural gas prices in North America. The gas producers have held supply constant—even in the face of $2/mcf gas—of roughly 64 bcf/d (billion cubic feet per day) this year. Power companies have increased demand by about 6 bcf/d in 2012—even in the spring, before the torrid summer heatwave began.

That represents just under 10% of total US demand. They are the big swing vote. Without them, gas would still be under $2/mcf.

So if the power producers switch back to coal, the natural gas rally could get halted dead in its tracks.

"I would predict that if the price of natural gas climbs sustainably above US$3.25, some 10 per cent of that switched would switch back to coal. And that percent would climb if prices rose to US$4," said energy veteran Thomas Drolet, who is formerly head of Ontario Hydro International.

When natural gas prices started falling from averages of around US$4.50 per mmBtu in January 2012, power generators started switching to the cheaper fuel from coal.

I follow the natural gas markets closely, but I'm not an engineer. So I wanted to know—logistically, how easy is it for these big electricity companies to switch back from natural gas to coal?

Well, it's as easy as changing a nozzle.

In most power plants, fuel is pushed to boilers via nozzles. The nozzles either spray powdered coal or natural gas to ignite and heat up tubes with water circulating in them. The steam generated by the hot water drives the turbines, which in turn generate electricity.

It's quite simple to change nozzles to accommodate different diameters and pressures. Many plants can handle both gas and coal and can move from one to another in a matter of hours—as in one, eight-hour shift. Older plants can take days, however.

As well, access to natural gas for a change-over to coal would be an issue if the power plant is not located close to a pipeline system, Drolet noted.

So, as natural gas prices are now rising-up to $3.50/mmBtu (1 mmBtu ~ 1.1 mcf), coal prices have dropped to around US$52 per ton from US$78 per ton, the equivalent of US$2.03 per mmBtu.

The $1.40+ per mmBtu discount to natural gas this week is the largest relative price difference since August 2011, according to Reuters data—providing, on paper at least, lots of incentive for electricity producers to start switching back and reducing natural gas demand—potentially a lot.

However, the tipping price point for fuel switching depends on the utility and the age of the generator.

The Future of Natural Gas Prices

The U.S. Energy Information Administration predicts natural gas consumption, which is estimated to rise by 5% this year from 2011 on power generation demand, will reverse in 2013 as prices rise and utilities switch back to coal.

"Because of the projected increase in natural gas prices relative to coal, EIA expects the recent trend of substituting coal-fired electricity generation with natural gas generation to slow and likely reverse over the next year," the agency said in its September short-term energy

"EIA expects that coal-fired electricity generation will increase by nine percent in 2013, while natural gas generation will fall by about 10 percent."

The other side of the coin is voiced by Ziff Energy analysts in Calgary, Alberta, who argue rising volumes of natural gas—produced as associated gas with shale oil and natural gas liquids, as well as shale gas—will conspire to put a ceiling on prices, despite low drilling activity on both sides of the border.

"We see a lot of production in the system and many wells waiting for pipelines to be built and to connect to," said Ziff's Senior Manager of Gas Services, Cameron Gingrich. "We're seeing a big surge in Marcellus and other shale, so taking everything into account, I don't see gas supply dropping any time soon—or prices rising."

Drolet also suggests U.S. power generators could also move to natural gas because of looming emissions limitations by the Environmental Protection Agency.

Utilities such as Minnesota's Xcel Energy said they would shut down smaller coal-fired power plants, saying natural gas-fired facilities were cheaper to build than installing costly pollution control equipment on existing coal units.

Ohio-based American Electric Power Company recently said it has burned a quarter less coal in the past four years, about 55 million tons in 2012 from 75 million tons in 2008, while doubling natural gas use.

"However, should natural gas, as some people believe, increase to an average of US$3.25, then price really becomes the primary reason, especially the more coal prices fall," Drolet concludes. And the market is there now.

Keith Schaefer
Oil & Gas Investments Bulletin


Get Our Streetwise Reports Newsletter Free and be the first to know!

A valid email address is required to subscribe